Henny-penny EEE-143 User Manual

Henny PennyEvolution Elite™Reduced Oil Capacity Open Fryers(Split Vat & Full Vat– Electric)Model EEE-141Model EEE-142Model EEE-143Model EEE-144OPE

Model EEE-141,142, 143, 144The proper location of the fryer is very important for operation,speed, and convenience. The location of the open fryer sh

Model EEE-141,142, 143, 144The fryer should be located with provision for venting into adequateexhaust hood or ventilation system. This is essential t

Model EEE-141,142, 143, 1442-6. ELECTRICAL REQUIREMENTS (Continued)An all pole, separate disconnect switch, with proper capacityfuses or break

Model EEE-141,142, 143, 144510 2-52-7. DIMENSIONSAuto-Lift FryersFront to rear dimension is 36-7/8 (93.66 cm).For doorways 36 in. (91.44 cm) o

Model EEE-141,142, 143, 144Figure 3-13-1 110SECTION 3. OPERATION3-1. OPERATING COMPONENTS Refer to explanations on the next pages.12 645738913

Model EEE-141,142, 143, 144110 3-2Fig. Item Description FunctionNo. No.3-1 1 This LED lights when the control calls for heat for the leftvat(s)

Model EEE-141,142, 143, 1443-3 1103-1. OPERATING COMPONENTS (Continued)Fig. Item Description FunctionNo. No.3-1 10 & 11 Each product butto

Model EEE-141,142, 143, 144Fig. Item Description FunctionNo. No.3-5 1 Filter Drain Pan Assy. Oil is drained into this pan and then is pumpedthrough fi

Model EEE-141,142, 143, 144Upon initial start-up, the controls will ask to confirm the settings forthe fryer.When the main power switch is turned on,

Model EEE-141,142, 143, 1443-3. FILLING OR ADDING OILThe oil level must always be above the heating elementswhen the fryer is heating and at t

Model EEE-141,142, 143, 1441. Make sure basket support is in vat and the vat is filled with oilto the proper level.Model EEE-141, fill the oil reservo

Model EEE-141,142, 143, 1443-5. BASIC OPERATIONThe Evolution Elite fryer is availalble as non-auto-lift and auto-liftmodels. The auto-lift controls,

Model EEE-141,142, 143, 1443-9 510During normal operation, the control automatically monitors theoil level in the vat. If the control senses th

Model EEE-141,142, 143, 1443-10. MODEL EEE-141 OILRESERVOIRFilling Oil Reservoir1. Control displays “JIB IS LOW” and an alarm sounds.2. Open door and

Model EEE-141,142, 143, 1443-11. SMARTFILTER EXPRESS™ 1. During normal operation and after a certain number ofcook cycles, the Filter Beacon® illumi

Model EEE-141,142, 143, 1447. If the oil has not pumped back to the proper level in the vatduring the SmartFilter Express™ process, press X button for

Model EEE-141,142, 143, 144This filtering procedure allows for a more thorough cleaning of thevat and should be done once a day. The vat can be filte

Model EEE-141,142, 143, 1446. Once oil has drained from vat, use the lift tool and lift the hingedelement from the vat to clean the bottom of the vat.

Model EEE-141,142, 143, 1443-12. DAILY FILTERING(Continued)12. Press √√√√√ button for YES if another rinse is needed, otherwisepress X button for NO

Model EEE-141,142, 143, 1443-13. DISCARDING OILFROM VAT USINGOPTIONAL OILDISCARD SHUTTLEFigure 1Figure 2WITH PROLONGED USE, THE FLASHPOINT OFOIL IS

FM05-053-F5-19-10LIMITED WARRANTY FOR HENNY PENNY EQUIPMENTSubject to the following conditions, Henny Penny Corporation makes the following limited wa

Model EEE-141,142, 143, 1443-14. OPERATING INSTRUC-TIONS FOR OPTIONALBULK OIL DISPOSALSYSTEM3-17 10091. Connect the female quick disconnect, th

Model EEE-141,142, 143, 1443-15. CHANGING THE FILTERPADIn order to assure good oil pumping performance, the filter pad (orpaper) should be changed at

Model EEE-141,142, 143, 1443-15. CHANGING THE FILTERPAD (Continued)5. Remove the filter pad retaining ring and clean thoroughly withsoap and water.

Model EEE-141,142, 143, 1443-15. CHANGING THE FILTERPAD (Continued)Be sure that the drain pan, bottom screen, crumb catcher,and the retaining ring a

Model EEE-141,142, 143, 1443-17. CLEAN-OUT MODEThe filter drain pan must be as far back under fryer as itwill go, and the cover in place. Be sure

Model EEE-141,142, 143, 144If vat still has oil, press X button and display shows “DISPOSE”“YES NO”. Press √√√√√ button to dispose of the oil, or pre

Model EEE-141,142, 143, 144To avoid burns when pouring hot solution, wear glovesand protective gear and take care to avoid splashing.11. Return empty

Model EEE-141,142, 143, 1443-18. CHECK/REPLACE FILTERDRAIN PAN O-RINGS17. Thoroughly dry the vat with a towel, and then press the √√√√√button. Cont

Model EEE-141,142, 143, 1443-19. INFO BUTTON STATS Actual Oil Temperature1. Press and the actual oil temperature shows in thedisplay, for e

Model EEE-141,142, 143, 144As in all food service equipment, the Henny Penny open fryer doesrequire care and proper maintenance. The table below prov

Model EEE-141,142, 143, 144 TABLE OF CONTENTSSection PageSection 1. INTRODUCTION ...

Model EEE-141,142, 143, 144SECTION 4. INFORMATION MODEThis historic information can be recorded and used for operationaland technical help and allow

Model EEE-141,142, 143, 1442. LAST LOAD (Information on recent cook cycles)Press and “2. LAST LOAD” show in displays.Press a timer button

Model EEE-141,142, 143, 1444-1. INFORMATION MODE DETAILS (Continued)3. DAILY STATS (Operational info of fryer for last 7 days)Press

Model EEE-141,142, 143, 144Start date of new oil NEW OIL MAR-23Number of days oil in use (L/R) OIL USE 4 DAYSNumber of filters on this oil (L/R) FILT

Model EEE-141,142, 143, 144Day the usage data was previously reset SINCE APR-19 3:00PNumber of Hours the fryer was on (L/R) ON HRS 4Number of times f

Model EEE-141,142, 143, 144This mode allows you to program the following:1. Press and hold button until “PROG” shows in thedisplay, followe

Model EEE-141,142, 143, 144To Change Times and Temperatures7. Press button until “COOK TIME” shows in the display,and then use the product b

Model EEE-141,142, 143, 144Mixed Filter TrackingFilter After X Number of Loads13b. Press button until “FILTER AFTER...” flashes in theleft

Model EEE-141,142, 143, 1446-1 1009SECTION 6. LEVEL 2 PROGRAMMINGThe Special Program Mode is used to set more detailedprogramming, such as:SP-1

Model EEE-141,142, 143, 144Press and hold the button for 5 seconds until “LEVEL 2”followed by, “SP PROG” and “ENTER CODE” show in thedisplay

Model EEE-141,142, 143, 144TABLE OF CONTENTS (Continued)Section PageSection 6. LEVEL 2 PROGRAMMING ...

Model EEE-141,142, 143, 1446-1. SPECIAL PROGRAMMODE (Continued)Audio Tone (SP-5)Press button and “SP-5” and “TONE” flash in theleft display.

Model EEE-141,142, 143, 144Filter Tracking Mode (SP-8)Filter Tracking signals the operator when the oil needs filtering bycounting the number Cook Cyc

Model EEE-141,142, 143, 1446-1. SPECIAL PROGRAMMODE (Continued)Filter Tracking Mode (SP-8) (Continued)GLOBALIf GLOBAL is selected, press

Model EEE-141,142, 143, 1446-1. SPECIAL PROGRAMMODE (Continued)Polish Duration (SP-9)Press button and “SP-9” and “POLISH TIME” flash inthe l

Model EEE-141,142, 143, 1446-1. SPECIAL PROGRAMMODE (Continued)2nd Language (SP-16)Press button and “SP-16 2ND LANGUAGE” flasheson the left

Model EEE-141,142, 143, 1446-1. SPECIAL PROGRAMMODE (Continued)Autolift Enabled (SP-21)Press button and “SP-21 AUTOLIFT ENABLED?”flashes in

Model EEE-141,142, 143, 144Program Code Change (SP-25) (Continued)If satisfied with code, press and “*CODE CHANGED*”shows in display.If not s

Model EEE-141,142, 143, 1446-2. CLOCK SET 1. Press and hold the button for 5 seconds until “LEVEL 2”,followed by, “SP PROG” and “ENTER CODE

Model EEE-141,142, 143, 1447-1. TROUBLE SHOOTING GUIDEProblem Cause CorrectionSECTION 7. TROUBLESHOOTINGPOWER switch ON butfryer completely inope

Model EEE-141,142, 143, 1447-1. TROUBLE SHOOTING GUIDE (Continued)Oil foaming or boilingover top of vatOil will notdrain from vatFilter mo

Model EEE-141,142, 143, 144The Henny Penny reduced oil capacity open fryer is a basic unit offood processing equipment. This unit is used only in inst

Model EEE-141,142, 143, 1447-2. ERROR CODES In the event of a control system failure, the digital display shows anerror message. The message codes

Model EEE-141,142, 143, 1447-2. ERROR CODESDISPLAY CAUSE CORRECTION“E-21” Slow heat recovery Have a certified service technician check the fryer f

*FM05-053-F* Henny Penny Corp., Eaton, Ohio 45320, Revised 5-19-10Henny Penny CorporationP.O.Box 60Eaton,OH 453201-937-456-84001-937-456-8402 FaxTol

Model EEE-141,142, 143, 1441-4. SAFETY The Henny Penny open fryer has many safety features incorporated.However, the only way to ensure a safe oper

Model EEE-141,142, 143, 1441-4. SAFETY (Continued)Equipotential Ground SymbolWaste Electrical and Electronic Equipment (WEEE) SymbolShock Haza

Model EEE-141,142, 143, 144SECTION 2. INSTALLATIONThis section provides the installation and unpacking instructions forthe Henny Penny open fryer.I