Henny-penny EVOLUTION ELITE EEG-141 User Manual

OPERATOR’S MANUALREGISTER WARRANTY ONLINE AT WWW.HENNYPENNY.COMHenny PennyEvolution Elite™Reduced Oil Capacity Open Fryers(Split Vat & Full Vat– G

Model EEG-141, 142, 143, 1441-4. ASSISTANCE Should you require outside assistance, call your local independentdistributor in your area, or call H

Model EEG-141, 142, 143, 1441-5. SAFETY (Continued)Equipotential Ground SymbolWaste Electrical and Electronic Equipment (WEEE) SymbolShock H

Model EEG-141, 142, 143, 144SECTION 2. INSTALLATIONThis section provides the installation and unpacking instructions forthe Henny Penny Evolution

The proper location of the fryer is very important for operation,speed, and convenience. The location of the open fryer shouldallow clearances for se

Model EEG-141, 142, 143, 144The fryer should be located with provision for venting into anadequate exhaust hood or ventilation system. This is essen

Model EEG-141, 142, 143, 1442-6. GAS SUPPLY (Continued)• The fryer and its manual shutoff valve must bedisconnected from the gas supply pipin

Model EEG-141, 142, 143, 144609 2-52-6. GAS SUPPLY (Continued)

Model EEG-141, 142, 143, 1442-7. GAS LEAK TEST2-8. GAS PRESSURE REGULATOR SETTING2-9. ELECTRICAL REQUIREMENTSPrior to turning the gas s

Model EEG-141, 142, 143, 1442-9. ELECTRICAL REQUIREMENTS (Continued)To avoid electrical shock, do not disconnect the ground(earth) plug. Th

Model EEG-141, 142, 143, 1442-12. DIMENSIONS2-8 510

Model EEG-141, 142, 143, 144Figure 3-13-1 1009SECTION 3. OPERATION3-1. OPERATING COMPONENTS Refer to explanations on the next pages.12 645 73

Model EEG-141, 142, 143, 144809 3-2Fig. Item Description FunctionNo. No.3-1 1 This LED lights when the control calls for heat for the leftvat

Model EEG-141, 142, 143, 1443-3 10093-1. OPERATING COMPONENTS (Continued)Fig. Item Description FunctionNo. No.3-1 9 Press to turn on and off t

Model EEG-141, 142, 143, 144Fig. Item Description FunctionNo. No.3-4 1 Filter Drain Pan Assy. Oil is drained into this pan and then is pumped throug

Model EEG-141, 142, 143, 1443-5 8093-2. SET-UP MODEUpon initial start-up, the controls will ask to confirm the settings forthe fryer.When the

Model EEG-141, 142, 143, 1443-3. FILLING OR ADDING OILThe oil level must always be above the burner tubes whenthe fryer is heating and at th

Model EEG-141, 142, 143, 1441. Make sure basket support is in vat and vat is filled with oil tothe proper level.Model EEG-141, fill the oil reservoi

Model EEG-141, 142, 143, 144809 3-83-5. BASIC OPERATION 1. Once out of the Melt Cycle, LOW TEMP flashes until the set-point temperature has

Model EEG-141, 142, 143, 144To avoid a fire, keep appliance area free and clear from combustibles. Improper installation, adjustment, alteration, se

Model EEG-141, 142, 143, 1443-9 510During normal operation, the control automatically monitors theoil level in the vat. If the control senses

Model EEG-141, 142, 143, 144Filling Oil Reservoir1. Control displays “JIB IS LOW” and an alarm sounds.2. Open door and pull reservoir forward and re

Model EEG-141, 142, 143, 1443-11. SMARTFILTER EXPRESS™ 1. During normal operation and after a certain number of cookcycles, the Filter Beacon® ill

Model EEG-141, 142, 143, 1446. If the oil has not pumped back to the proper level in the vatduring the SmartFilter Express™ process, press X button

Model EEG-141, 142, 143, 1443-13 809This filtering procedure allows for a more thorough cleaning of thevat and should be done once a day. The

Model EEG-141, 142, 143, 144809 3-147. Scrape or brush the sides and the bottom of the vat. Becareful not to damage the sensing probes.Do not

Model EEG-141, 142, 143, 1443-15 8093-13. DISCARDING OILFROM VAT USINGOPTIONAL OILDISCARD SHUTTLEWITH PROLONGED USE, THE FLASHPOINT OFOIL IS

Model EEG-141, 142, 143, 144Figure 1Figure 23-14. DISCARDING OILFROM VAT USINGOPTIONAL BULK OILDISPOSE SYSTEM1009 3-161. Connect the female q

Model EEG-141, 142, 143, 1443-15. CHANGING THE FILTERPADIn order to assure good oil pumping performance, the filter pad (orpaper) should be changed

Model EEG-141, 142, 143, 1443-15. CHANGING THE FILTERPAD (Continued)5. Remove the filter pad retaining ring and clean thoroughly withsoap and wate

Model EEG-141, 142, 143, 144Technical Data for CE Marked ProductsNominal Heat Input: Natural (I2H) = 19,8, kW (67,560 Btu/h)(Net) Natural (I2E) = 19

Model EEG-141, 142, 143, 1443-15. CHANGING THE FILTERPAD (Continued)Be sure that the drain pan, bottom screen, crumb catcher,and the retaining rin

Model EEG-141, 142, 143, 144609 3-203-17. CLEAN-OUT MODEThe filter drain pan must be as far back under fryer as itwill go, and the cover in

Model EEG-141, 142, 143, 1443-21 609Display shows “IS DISPOSAL UNIT IN PLACE?” “YESNO”. If “NO” is selected, display shows “INSERT DISPOSALU

Model EEG-141, 142, 143, 144609 3-2211. Return empty filter drain pan to fryer and press √√√√√ button.Display then shows “VAT EMTY” “YES NO”.12

Model EEG-141, 142, 143, 1443-23 6093-18. CHECK/REPLACE FILTERDRAIN PAN O-RINGSTo prevent oil leaking, and to keep filtering process operati

Model EEG-141, 142, 143, 144609 3-243-19. INFO BUTTON STATS Actual Oil Temperature1. Press and the actual oil temperature shows in t

Model EEG-141, 142, 143, 1443-25 609As in all food service equipment, the Henny Penny open fryer doesrequire care and proper maintenance. The

Model EEG-141, 142, 143, 144To ensure proper burner operation, clean the blowers and blowervents twice a year.1. Press the main power switch to the

Model EEG-141, 142, 143, 144609 4-1SECTION 4. INFORMATION MODEThis historic information can be recorded and used for operationaland technic

LIMITED WARRANTY FOR HENNY PENNY EQUIPMENTSubject to the following conditions, Henny Penny Corporation makes the following limited warranties to the o

Model EEG-141, 142, 143, 1444-2 6092. LAST LOAD (Information on recent cook cycles)Press and “2. LAST LOAD” show in displays.Press

Model EEG-141, 142, 143, 144609 4-34-1. INFORMATION MODE DETAILS (Continued)3. DAILY STATS (Operational info of fryer for last 7 d

Model EEG-141, 142, 143, 1444-4 609Start date of new oil (L/R) NEW OIL MAR-23Number of days oil in use (L/R) OIL USE 4 DAYSNumber of filters o

Model EEG-141, 142, 143, 144609 4-5Day the usage data was previously reset SINCE APR-19 3:00PNumber of Hours the fryer was on (L/R) ON HRS 4

Model EEG-141, 142, 143, 1445-1 609This mode allows you to program the following:1. Press and hold button until “PROG” shows in the

Model EEG-141, 142, 143, 144To Change Times and Temperatures7. Press button until “COOK TIME” shows in the display,and then use the produc

Model EEG-141, 142, 143, 144Mixed Filter TrackingFilter After X Number of Loads13b. Press button until “FILTER AFTER...” flashes in thele

Model EEG-141, 142, 143, 1441009 6-1SECTION 6. LEVEL 2 PROGRAMMINGThe Special Program Mode is used to set more detailedprogramming, such as

Model EEG-141, 142, 143, 144Press and hold the button for 5 seconds until “LEVEL 2”followed by, “SP PROG” and “ENTER CODE” show in thedisp

Model EEG-141, 142, 143, 144Audio Tone (SP-5)Press button and “SP-5” and “TONE” flash in theleft display. Press the or , or use pr

Model EEG-141, 142, 143, 144 TABLE OF CONTENTSSection PageSection 1. INTRODUCTION ...

Model EEG-141, 142, 143, 144Filter Tracking Mode (SP-8)Filter Tracking signals the operator when the oil needs filtering bycounting the number Cook

Model EEG-141, 142, 143, 1446-1. SPECIAL PROGRAMMODE (Continued)Filter Tracking Mode (SP-8) (Continued)GLOBALIf GLOBAL is selected, press

Model EEG-141, 142, 143, 1446-1. SPECIAL PROGRAMMODE (Continued)Polish Duration (SP-9)Press button and “SP-9 POLISH TIME” flashes inthe lef

Model EEG-141, 142, 143, 1446-1. SPECIAL PROGRAMMODE (Continued)2nd Language (SP-16)Press button and “SP-16 2ND LANGUAGE” flasheson the le

Model EEG-141, 142, 143, 1446-1. SPECIAL PROGRAMMODE (Continued)Autolift Enabled (SP-21)Press button and “SP-21 AUTOLIFT ENABLED?”flashes

Model EEG-141, 142, 143, 144Program Code Change (SP-25) (Continued)If satisfied with code, press and “*CODE CHANGED*”shows in display.If no

Model EEG-141, 142, 143, 1446-2. CLOCK SET 1. Press and hold the button for 5 seconds until “LEVEL 2”,followed by, “SP PROG” and “ENTER C

Model EEG-141, 142, 143, 144SECTION 7. TROUBLESHOOTING7-1. TROUBLE SHOOTING GUIDEProblem Cause CorrectionPOWER switch ON butfryer completely in

Model EEG-141, 142, 143, 1447-1. TROUBLE SHOOTING GUIDE (Continued)Oil foaming or boilingover top of vatOil will notdrain from vatFilter

Model EEG-141, 142, 143, 1447-2. ERROR CODES In the event of a control system failure, the digital display shows anerror message. The message co

Model EEG-141, 142, 143, 144TABLE OF CONTENTS (Continued)Section PageSection 4. LEVEL 1 PROGRAMMING ...

Model EEG-141, 142, 143, 1447-2. ERROR CODES “E-20-A” • Pressure Switch • If fan is not running, have pressure switch checked; should be“FAN SEN

*FM05-057-* Henny Penny Corp., Eaton, Ohio 45320, Revised 5-28-10Henny Penny CorporationP.O.Box 60Eaton,OH 453201-937-456-84001-937-456-8402 FaxTol

Model EEG-141, 142, 143, 1441-1. INTRODUCTION The Henny Penny open fryer is a basic unit of food processingequipment designed to cook foods bette