Henny-penny OFE-321 User Manual Page 1

TECHNICAL MANUALHenny Penny CFA Electric Open Fryer Model OFE-321 Model OFE-322

Model OFE-321,322 1-4. WARNINGS AND ERROR MESSAGES (Continued) ERROR CODES DISPLAY CAUSE CORRECTION “E-4”

Model OFE-321,322 3-5. WARNINGS AND ERROR MESSAGES (Continued) ERROR CODES DISPLAY CAUSE CORRECTION “E-41”

Model OFE-321,322 SECTION 2. MAINTENANCE 2-1. INTRODUCTION This section provides procedures for the checkout and replacement

Model OFE-321,322 2-4. POWER SWITCH 1. Remove electrical power supplied to fryer. To avoid electrical s

Model OFE-321,322 2-6. I/O POWER SUPPLY BOARD ASSEMBLY The input/output power supply board assembly distributes vo

Model OFE-321,322 2-7. DRAIN MICROSWITCH (Continued) 2. The following check should be made to determine if the drain microswitch is d

Model OFE-321,322 2-9. HEATING ELEMENTS Heating elements are available for 208, 480 and 230 volts. Check data pl

Model OFE-321,322 2-9. HEATING ELEMENTS (Continued) 3. Remove the heating element wires from the terminals by rem

Model OFE-321,322 2-9. HEATING ELEMENTS (Continued) 13. Connect the power cord to the wall receptacle or close wall ci

Model OFE-321,322 2-10. HEATING CONTACTORS Each well of an electric fryer requires two switching contactors

Model OFE-321,322 2-10. HEATING Checkout (Power Supplied) CONTACTORS (Continued)

Model OFE-321,322 Electromechanical Contactor Replacement: If either contactor is defective it must be replaced as fo

Model OFE-321,322 2-12. HIGH TEMPERATURE LIMIT CONTROL The electric units, models OFE-321/2/3/4, use the same high

Model OFE-321,322 9. Insert new 425 degree high limit, part no. 60241 and replace screws. 2-11 10.

Model OFE-321,322 2-13 707

Model OFE-321,322 707 2-14

Model OFE-321,322 LIMITED WARRANTY FOR HENNY PENNY APPLIANCES Subject to the following conditions, Henny Penny Corporation makes the f

Model OFE-321,322 SECTION 3. PARTS INFORMATION 3-1. INTRODUCTION This section lists the replaceable parts of the Henny Penny

Model OFE-321,322 Figure 3-1. Electric Heat Controls 3-2 405

Model OFE-321,322 FIGURE & PART NO. DESCRIPTION QTY. PER UNIT ITEM NO. 321 322 3-1 ELECTRIC HEAT CONTROLS √ 1 268

Model OFE-321,322 TABLE OF CONTENTS Section

Model OFE-321,322 Figure 3-2. Side, Top, & Rear Panels 3-4 109

Model OFE-321,322 FIGURE & PART NO. DESCRIPTION QTY. PER UNIT ITEM NO. 321 322 3-2 SIDE, TOP, AND REAR PANELS 1

Model OFE-321,322 Figure 3-3. Oil Filtering System 3-6 405

Model OFE-321,322 FIGURE & PART NO. DESCRIPTION QTY. PER UNIT ITEM NO. 321 322 3-3 OIL FILTERING SYSTEM 1 66005

Model OFE-321,322 Figure 3-4. Door, Switches, Menu Card, & Control Board 3-8 1005

Model OFE-321,322 FIGURE & PART NO. DESCRIPTION QTY. PER UNIT ITEM NO. 321 322 3-4 DOOR, SWITCHES, MENU CARD, &

Model OFE-321,322 Figure 3-5. Baskets and Return Faucet 3-10 405

Model OFE-321,322 FIGURE & PART NO. DESCRIPTION QTY. PER UNIT ITEM NO. 321 322 3-5 BASKETS AND RETURN FAUCET 1 2

Model OFE-321,322 Figure 3-6. Shrouds and Pot & Counter Top 3-12 405

Model OFE-321,322 FIGURE & PART NO. DESCRIPTION QTY. PER UNIT ITEM NO. 321 322 3-6 SHROUDS AND POT & COUNTER T

Model OFE-321,322 Figure 3-7. Electric Heater 3-14 405

Model OFE-321,322 FIGURE & PART NO. DESCRIPTION QTY. PER UNIT ITEM NO. 321 322 3-7 ELECTRIC HEATER √ 1 30292-2 H

Model OFE-321,322 Figure 3-8. Drain Pan, Screen, and Cover 3-16 1005

Model OFE-321,322 FIGURE & PART NO. DESCRIPTION QTY. PER UNIT ITEM NO. 321 322 3-8 DRAIN PAN, SCREEN, & COVER

Model OFE-321,322 Figure 3-9. Autolift Feature 3-18 109

Model OFE-321,322 FIGURE &. PART NO. DESCRIPTION QTY. PER UNIT ITEM NO. 321 322 3-12 AUTOLIFT FEATURE 1 50814 FRYPO

Model OFE-321,322 SECTION 1. TROUBLESHOOTING 1-1. INTRODUCTION This section provides troubleshooting information in the form of an

Model OFE-321,322 1-3. TROUBLESHOOTING To isolate a malfunction, proceed as follows: 1. Clearly define the problem, or

Model OFE-321,322 1-3. TROUBLESHOOTING(Continued) PROBLEM CAUSE CORRECTION Heating of • Low or improper • Use a meter an

Model OFE-321,322 1-3. TROUBLESHOOTING (Continued) PROBLEM CAUSE CORRECTION Shortening will not • Drain valve clogg

Model OFE-321,322 1-4. WARNINGS AND The controls monitor procedure problems and system failures ERROR MESSAGES with warnings an